2004 VOLVO S60 Recall ID from NHTSA: 04V029000
| Auto Recall Date: |
JAN 16, 2004 |
| Vehicle Component: |
STEERING:LINKAGES |
| Model Affected |
S60 |
| Estimated Vehicles Affected: |
29986
Recall Details
|
Auto Recall Date:
JAN 16, 2004
Vehicle Component:
STEERING:LINKAGES
Estimated Vehicles Affected:
29986
Model Affected
2004 VOLVO S60
2004 Volvo S60 Defect Summary:
ON CERTAIN PASSENGER VEHICLES, THE FRONT CONTROL ARMS MAY NOT HAVE BEEN MANUFACTURED CORRECTLY AND, AS A RESULT, THE STUD AND NUT THAT SECURE THE ARM TO THE SPINDLE MAY LOSE THEIR INITIAL AXIAL TENSION. UNDER CERTAIN DRIVING CONDITIONS, THE STEERING MAY BECOME LESS RESPONSIVE AND THE DRIVER MAY EXPERIENCE STEERING WHEEL PLAY.
Defect Consequence:
THIS DRIVING CONDITION COULD EVENTUALLY LEAD TO SEPARATION BETWEEN THE FRONT CONTROL ARM AND THE SPINDLE, WHICH COULD RESULT IN A CRASH.
Remedy:
DEALERS WILL INSTALL A NEW TYPE OF NUT. OWNER NOTIFICATION BEGAN ON FEBRUARY 16, 2004. OWNERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
Estimated Vehicles Affected:
29986
Notes:
VOLVO CARS OF N.A. LLC. R133
2004 VOLVO S60 Recall ID from NHTSA: 07E023000
| Auto Recall Date: |
MAR 29, 2007 |
| Vehicle Component: |
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER |
| Model Affected |
S60 |
| Estimated Vehicles Affected: |
13128
Recall Details
|
Auto Recall Date:
MAR 29, 2007
Vehicle Component:
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
Estimated Vehicles Affected:
13128
Model Affected
2004 VOLVO S60
2004 Volvo S60 Defect Summary:
CERTAIN CARDONE MASTER CYLINDERS WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Defect Consequence:
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy:
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Estimated Vehicles Affected:
13128
Notes:
CARDONE INDUSTRIES, INC.
2004 VOLVO S60 Recall ID from NHTSA: 07V226000
| Auto Recall Date: |
JUN 05, 2007 |
| Vehicle Component: |
ENGINE AND ENGINE COOLING |
| Model Affected |
S60 |
| Estimated Vehicles Affected: |
38700
Recall Details
|
Auto Recall Date:
JUN 05, 2007
Vehicle Component:
ENGINE AND ENGINE COOLING
Estimated Vehicles Affected:
38700
Model Affected
2004 VOLVO S60
2004 Volvo S60 Defect Summary:
ON CERTAIN PASSENGER VEHICLES, THE FUEL PRESSURE SENSOR LOCATED ON THE LEFT END OF THE FUEL RAIL MAY, AT TIMES, TRANSMIT INCORRECT SIGNAL REGARDING THE FUEL PRESSURE TO THE ENGINE CONTROL MODULE. IF THE SIGNAL IS OUTSIDE OF THE PRE-PROGRAMMED ALLOWABLE LIMITS, A DIAGNOSTIC TROUBLE CODE MAY BE SET AND THE CHECK ENGINE LIGHT WILL COME ON. THE SOLDERED JOINTS ON THE CIRCUIT BOARD OF THE FUEL PRESSURE SENSOR MAY CRACK DUE TO TEMPERATURE CHANGES AND EXCESSIVE VIBRATIONS.
Defect Consequence:
MISFIRE MAY OCCUR DURING DRIVING THAT, IN TURN, WILL REDUCE THE ENGINE TORQUE AND IN THE WORST CASE SCENARIO, THE ENGINE MAY STALL WITHOUT WARNING. IN CERTAIN TRAFFIC SITUATIONS THIS COULD CAUSE AN UNSAFE SITUATION AND POSSIBLY A CRASH.
Remedy:
DEALERS WILL REPLACE THE FUEL PRESSURE SENSOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 29, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Estimated Vehicles Affected:
38700
Notes:
VOLVO CARS OF N.A. LLC. R181